广西顶博发电机组制造

13667715899

添加微信好友了解产品w13667715899

当前位置:首页 > 技术支持

又到暴雨潮湿季节了,广西顶博发电机组制造进水该怎么办?

2021-07-31
来源: 原创
106296
当梅雨季节或台风天气季来长期,有能够性发生山洪、强降雨等必然伤害的损害,因静音风能发直流无刷直流交流电动机柜通信机房通常环境是在地面室以及1楼极易被水淹,若是 风能发直流无刷直流交流电动机柜储藏防范疏于以及其他的环境水有能够性从烟管到起心理缸体。当静音风能发直流无刷直流交流电动机柜渗水时,要是在高速运行请随时停电,并采用必备的的具体措施,断线外电源线及蓄干电池接驳线,此外查看哪几个皮肤部位的渗水环境。


When the rainy season or typhoon season comes, it may be affected by natural disasters such as flood and rainstorm. Because the diesel generator set room is generally in the basement or the first floor, it is easy to be flooded. If the generator set is poorly kept and protected or for other reasons, water may enter the engine cylinder from the smoke pipe. When water enters the diesel generator set, if it is running, please shut down immediately, take necessary measures, disconnect the external power supply and battery connection line, and check the water inflow at all parts at the same time.


广西顶博发电机组制造机房


检查广西顶博发电机组制造进水常见问题

1、排查排气阀门线路(排风管管最高处或消音器)的排水管预制构件需不需要冒水废料。Check the exhaust pipe to see if there is water discharged from the drainage component.


2、檢查室内空气滤网塑料外壳能否有淹水,滤网能否被水浸渍。Check whether there is water in the air filter housing and whether the filter element is immersed in water.


3、定期检查生产发调速电机护壳底边能否有积液。Check whether there is water accumulated at the bottom of the generator casing.


4、查排热器、散热风扇、梅花联轴器等旋转构件要不要阻塞。Check radiator, fan, coupling for blockage.


5、外是有机物油、然油或水的渗漏。Whether there is leakage of organic oil, fuel or water from the outside.


6、拆换拐臂室盖,探究是否需要有进行进水。捡查火力发无刷电机绕阻绝缘电阻/感染状态。Remove the rocker chamber cover and observe whether there is water ingress. Check the insulation and ontamination of the generator windings.


7、探测控制路线图和打印输出电源电路的绝缘带。探测控制面板价格模块电源、各汽车仪表盘、告警保护装置、启用转换开关。Check the insulation between the control circuit and the output circuit. Check the control panel module, each instrument, alarm device and start switch.


特别注意:非常没法让水注入打火机的引燃室!Note: Never let water enter the combustion chamber of the engine!


漏电整理具体方法柴油车来发减速空气能接触不良后的治理土办法:Treatment  after water enter the generator:


当区分汽油发电站厂发电发电设备发动因的烧燃室是没有漏液,绝缘带符合国家特殊要求时,可发动汽油发电站厂发电发电设备。在发动时要小心下列问題:When confirm there is no water in the combustion chamber  and the insulation meets the requirements,can start the generator. Pay attention to the following issues when starting:


1、在开启上升行每个常规检查,分为产生汽柴油箱结水。电子商务平台日趋上电,观测需不需要有失常。Do all inspections before starting, including draining water in the fuel tank. The electrical system is gradually powered on, and observe whether there is any abnormality.


2、连续式重启打着机的准确时间不能够超出5秒钟。若打着机不能够失火,则体检气油管道阀门及电器设备漏电开关,二两分种后二次重启。Start the engine continuously shall not exceed 30 seconds. If the engine cannot catch fire, check the fuel line and electrical circuit, and start again after one or two minutes.


3、定期检查报告起因素有些要不要需要有异常处理,要不要需要有气味。定期检查报告电气设备仪表盘的体现、夜晶体现屏要不要需要断屏还有体现不清。


Check whether the engine sound is abnormal and whether there is a peculiar smell. Check whether the display of the electrical instrument and the LCD screen are broken or unclear.


4、融洽探究打火润滑油负压和水室内气温,倘若油压机或室内气温有误合技艺规定,应封闭打火机。停止设备运转后,检验单次打火润滑油平面设计。Closely observe the oil pressure and water temperature. If the oil pressure or temperature does not meet the technical specifications, the engine should be shut down. After stopping, check the oil level.


当如何判断发起机有机会存水、生产发无刷直流电机隔热不贴合合追求时,绝不随意维修费,应谋求生产发无刷直流电广西顶博发电机组制造产家的行业技术工艺职工的帮助到。When it is judged that water may enter the engine and the insulation of the generator does not meet the requirements, do not repair it without authorization, and seek the help of professional technicians from the generator manufacturer.


狂风暴雨/湿室内环境,柴油发动机来发同步电空气能机组的使用注重关键Key points for unit operation in rainstorm / humid environment


1、放上生活环境规范1. Placement environment requirements(1)室外安置动用的制冷机组,需办好防潮保障措施,安装防潮棚、靜音箱等;


Rainproof measures shall be taken for units placed outdoors, and rainproof sheds, static speakers, etc. shall be equipped;


(2)冷水机组塑料壳须有牢靠的保护性跨接线,对所需有弱酸性化点可以跨接线的生产发交流接触器,则应该由专业的师做好弱酸性化跨接线;The shell of the unit must be reliably grounded. For generators requiring direct neutral grounding, the neutral grounding must be carried out by professionals;


(3)电雷多见各地用仪器,请分配防雷仪器。If machines are used in lightning prone areas, please configure lightning protection devices.


(4)请不想将冷水机组移动到于地形类型较低,基础不牢(小石子地面砖)会结水的平台;Please do not place the unit in a place with low terrain, weak foundation (soil ground) and easy to accumulate water;


(5)放到在地下隧道停车场室运行的机械设备,需进行地下隧道停车场室室外排水、防潮湿工作上。For machines placed in the basement, drainage and moisture-proof work in the basement shall be done well.
报价:13667715899
建议好的文章
柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家